flue gas - wikipedia

Flue gas - Wikipedia

Jun 02, 2005· Flue gas is the gas exiting to the atmosphere via a flue, which is a pipe or channel for conveying exhaust gases from a fireplace, oven, furnace, boiler or steam generator.Quite often, the flue gas refers to the combustion exhaust gas produced at …

Get a Quote
boiler efficiency and combustion | spirax sarco

Boiler Efficiency and Combustion | Spirax Sarco

Accurate control of the amount of air is essential to boiler efficiency: Too much air will cool the furnace, and carry away useful heat. Too little air and combustion will be incomplete, unburned fuel will be carried over and smoke may be produced. In practice, however, there are a number of difficulties in achieving perfect (stoichiometric

Get a Quote
gas-fired boilers - code compliance brief | building

Gas-Fired Boilers - Code Compliance Brief | Building

A boiler typically uses a fuel such as natural gas, propane, or fuel oil in a vented combustion chamber, much like a furnace. Whereas a furnace directly transfers heat from combustion to supply air in the air distribution unit, a boiler heats a secondary transfer fluid (typically water, but sometimes steam) that is, in turn, pumped through a

Get a Quote
boiler fuel by exhaust air from generator

Boiler Fuel By Exhaust Air From Generator

2011-8-26 · Typically, turbine exhaust gases have 14% to 15% by volume of oxygen in the exhaust, which can be used as combustion air. Simply by adding fuel to a burner located in the gas stream, one can increase the exhaust gas temperature from the typical 900 °F to 1050 °F to as high as 2,500 °F to 3,000 °F, depending on boiler design.

Get a Quote
boiler efficiency | how to balance steam loads efficiently

Boiler Efficiency | How to balance steam loads efficiently

Aug 26, 2011· Typically, turbine exhaust gases have 14% to 15% by volume of oxygen in the exhaust, which can be used as combustion air. Simply by adding fuel to a burner located in the gas stream, one can increase the exhaust gas temperature from the typical 900 °F to 1050 °F to as high as 2,500 °F to 3,000 °F, depending on boiler design.

Get a Quote
emergency generators and combustion air by ian shapiro, pe

Emergency Generators and Combustion Air by Ian Shapiro, PE

the mechanical room where the generator is located and then to duct the air from the radiator back outdoors. This, in effect, makes the generator a large exhaust fan. Generators are often located in mechanical rooms along with natural draft (atmospheric burner) boilers and water heaters.

Get a Quote
solid fuel fired hot air generator - exportersindia

solid Fuel Fired Hot Air Generator - exportersindia

The AIRMAX series, horizontal four pass indirect fired shell and tube type hot air generator designed for maximum efficiency using a variety of solids fuels. It is designed with fuel flexibility in mind and can fire a range of use wood, coal, any type solid fuel. It allows low and medium process temperatures without operating pressures.

Get a Quote
application & installation guide engine room ventilation

Application & Installation Guide Engine Room Ventilation

Jul 13, 2016· air is needed for more than just the engine; the generator intake also requires cool clean air. The most effective way to do this is to provide a ventilation air source low to the ground at the rear of the package. The use of insulation on exhaust pipes, silencers, and jacket water pipes will reduce the amount of heat radiated by auxiliary sources. Radiated heat from the engines

Get a Quote
fuels exhaust temperatures - engineering toolbox

Fuels Exhaust Temperatures - Engineering ToolBox

Related Topics . HVAC Systems - Heating, ventilation and air conditioning systems - design and dimensions; Combustion - Boiler house topics - fuels like oil, gas, coal, wood - chimneys, safety valves, tanks - combustion efficiency; Related Documents . Fuels - Combustion Air and Flue Gases - Combustion air and flue gas for common fuels - coke, oil, wood, natural gas and more

Get a Quote
ehs design guidelines for emergency generators

EHS Design Guidelines for Emergency Generators

fire pumps and more. The primary environment, health and safety issues relate to noise and generator air emissions. Most of the generators on the UNC Campus are powered by diesel fuel. Diesel generators emit NOx, hydrocarbons, particulates, CO and SOx. Diesel exhaust is considered a respiratory irritant and a suspect carcinogen.

Get a Quote
boiler emissions 101 - boiler service | boiler parts

Boiler Emissions 101 - Boiler Service | Boiler Parts

NOx What it is: NOx is a generic term for the chemical compounds made of nitrogen and oxygen.The air we breathe and use for combustion is 20.9% oxygen (O2); 79% nitrogen; and .1% other. In the combustion process, some of the nitrogen and oxygen in the air combine to create NOx.

Get a Quote
calculation methods of steam boiler operation factors

Calculation methods of steam boiler operation factors

Apr 15, 2020· Analyzed boiler with marked stream flows of fuel, air, ash, water, flue gas, and steam passed the boundary of control area: 1 – fuel, 2 – slag, 3 – ambient air, 4 – flue gas, 5 – feedwater, 6 – steam to reheat (from High-Pressure turbine), 7 – injection water to superheaters, 8 – injection water to reheaters, 9 – superheated

Get a Quote
basics of hot water heating boilers - specifying engineer

Basics of hot water heating boilers - Specifying Engineer

Sep 18, 2020· Waste heat from another process such as in internal combustion gas engine or turbine exhaust can be used as the heating source in lieu of burning fuel in a boiler. Another source of energy that could gain popularity is electricity. Hot water generated by an electric boiler produces no greenhouse gases at the site.

Get a Quote
combined heat and power technology fact sheet series

Combined Heat and Power Technology Fact Sheet Series

The recuperator is a heat exchanger that uses the hot turbine exhaust gas (typically around 1,200°F) to preheat the compressed air (typically around 300°F) going into the combustor, thereby reducing the fuel needed to heat the compressed air to the required turbine inlet temperature.

Get a Quote
design and installation of exhaust system of diesel

Design and Installation of Exhaust System of Diesel

The exhaust pipe mat not be connected to another generator set exhaust pipe or other pipe such as a stove or a boiler pipe. What are the reasons for the abnormal exhaust of diesel generator sets? For a well burned diesel generator set, the smoke from the exhaust pipe is colorless or light gray.

Get a Quote
fulton - the heat transfer innovators.

Fulton - The heat transfer innovators.

The Heat Transfer Innovators. Fulton is a global group of companies that specialize in industrial and commercial heating systems that include steam and hot water/hydronic boilers, thermal fluid (hot oil) heaters, and a full range of ancillary equipment.

Get a Quote
inert gas system for machinery installations onboard

Inert gas system for machinery installations onboard

The inert gas generator (Figure below) burns fuel in designed quantities to produce perfect combustion. This provides an exhaust gas which is largely nitrogen and carbon dioxide with a very small oxygen content. The exhaust gases pass to a cooling and washing chamber to …

Get a Quote
united states environmental protection agency | us epa

United States Environmental Protection Agency | US EPA

2.4-2 Example CEMS Output for a Boiler Burning No. 6 Fuel Oil.. 2.4-3 2.4-3 Fd Factors for Various Fuels This section provides a brief overview discussion of boilers. The reader is referred to the Air Pollution Engineering Manual (sometimes referred to as AP-40) (Buonicore and Davis, 1992)

Get a Quote
steam boiler|thermic fluid heater|power boiler|hot air

Steam Boiler|Thermic Fluid Heater|Power Boiler|Hot Air

We are India's leading Manufacturer of Steam Boiler,Thermic Fluid Heater,Co-generation Plant,Power Boiler,Multi-fuel Boiler,Bio-mass Boiler,Air Pollution Control Equipments,Hot Air Generaters,Thermopack,Agro Waste Boiler,Solid Fuel Boiler,Mobile Steam Generator,Multi Solid Fuel Fired FBC Incinerator, Husk Boilers, FBC Steam Boiler,FBC Hot Air Generator,FBC Thermic Fluid …

Get a Quote
aux. boiler - ohio epa

Aux. Boiler - Ohio EPA

CTG Combustion Turbine Generator HRSG Heat Recovery Steam Generator STG Steam Turbine Generator Air Fuel CTG Exhaust Stack Exhaust Fuel CTG Exhaust Stack Exhaust High P re ss u re Stea m Con d sate L ow Pres s ure St e a m Water Supply Water Blowdown Aux. Boiler Fuel Stack Exhaust Emergency Generator Fuel Stack Exhaust Fire Pump Stack Exhaust

Get a Quote
clean air tracking system - dep

Clean Air Tracking System - DEP

Clean Air Tracking System. Our Clean Air Tracking System (CATS) allows users to process new applications, renewals, amendments and all other air permit related actions. CATS Filing Instructions for Fossil Fuel Burning Boilers and Water Heaters. Generator or Combustion Source Registration.

Get a Quote
par techno-heat pvt. ltd. | steam boiler|thermic fluid

PAR TECHNO-HEAT PVT. LTD. | Steam Boiler|Thermic Fluid

We are India's leading Manufacturer of Steam Boiler,Thermic Fluid Heater,Co-generation Plant,Power Boiler,Multi-fuel Boiler,Bio-mass Boiler,Air Pollution Control Equipments,Hot Air Generaters,Thermopack,Agro Waste Boiler,Solid Fuel Boiler,Mobile Steam Generator,Multi Solid Fuel Fired FBC Incinerator, Husk Boilers, FBC Steam Boiler,FBC Hot Air Generator,FBC Thermic Fluid …

Get a Quote
flue gas dampers - california boiler

Flue Gas Dampers - California Boiler

Stainless steel or black steel flue gas dampers made by Jeremias are used in combined heat and power plants, emergency power systems, exhaust air technologies and in overpressure operation engines. Butterfly valve. Butterfly valves are used to close the exhaust air pipes in case of negative pressure and overpressure situation.

Get a Quote
heat recovery steam generator - wikipedia

Heat recovery steam generator - Wikipedia

A heat recovery steam generator (HRSG) is an energy recovery heat exchanger that recovers heat from a hot gas stream, such as a combustion turbine or other waste gas stream. It produces steam that can be used in a process ( cogeneration ) or used to drive a steam turbine ( combined cycle ).

Get a Quote